Whole-system duct and dryer vent check with before-and-after photos - you see exactly what came out of your vents
That "$99 whole-house special" is a bait ad - the real number appears once they are in your hallway, or the "clean" is a shop-vac at the register. We photograph the inside of your ducts before and after instead.
Before
After
Before
After
Before
AfterFast, Reliable Air Duct Repair Across Crowley
Air duct repair in Crowley usually runs between $220 and $680 for a typical flex duct reconnection and sealing job, with full air duct replacement on an average single-story home landing around $1,900 to $3,400. Those are real numbers for this market, not a teaser price. The catch in Crowley, unlike most suburbs, is that your slab foundation is slowly working against your ductwork. If you’ve noticed weak airflow from certain registers, a musty attic smell when the AC kicks on, or rooms that never quite cool down, call (980) 447-2498 and we’ll send a technician who knows exactly what to look for in Crowley homes.
Why Linden Air Duct Cleaning Is Crowley’s Preferred Air Duct Repair Company
We’ve spent enough time crawling through attics off McAlister Road, Deer Creek, and the neighborhoods south of Risinger Road to recognize the patterns that repeat in Crowley ductwork. The black gumbo clay under your slab is not something every repair company accounts for. We do, because we see the result every week: flex duct boots pulled off register boxes, return plenums cracked at the connection, and decades of North Texas particulate packed into trunk lines. When a Crowley homeowner calls us, the phone is answered by a live person, and the technician who arrives has already been introduced to you by name and photo. Our background-checked, identity-verified crews understand that letting someone into your home while you’re alone or with young kids is a real decision. That’s why every Linden technician follows the Threshold Standard: a photo ID badge shown at the door, a clean marked uniform, and a written price before any work starts. Marcus Veale, who leads our team, holds every job to the 365-Day Done Right Promise. If a repair fails, we return at no charge. That’s written on every invoice.
HVAC Duct Installation in Crowley
HVAC Duct Installation in Crowley means running new flex or rigid duct wherever the current runs have collapsed, disconnected, or degraded past the point of sealing. In Crowley, this typically becomes necessary when the black gumbo clay has shifted a slab enough to crush a duct run, or when 20-year-old mylar jackets have torn and the internal liner is sagging in multiple places. For a single trunk line replacement or a few new flex runs, expect to pay $350 to $900 depending on linear footage and access. A full home installation after a remodel or major failure runs $2,200 to $4,500 for a typical 1,600 to 2,400 square foot Crowley home.
Installation After Foundation Movement
When a slab shifts, the duct runs closest to the center of the home take the brunt of the stress. We often install new flex duct with reinforced boot connections and a more forgiving support interval than the original construction used. This is not a band-aid. It’s building the run so the next seasonal swell and shrink cycle doesn’t pull it apart the way the first one did.
New Runs for Remodeled or Split Systems
If you’re converting a garage into living space or adding a room off the back of a Crowley home, that space needs its own supply and return runs. We size the duct to the load, not to whatever happened to be in stock. A proper install includes sealed boots, mastic or approved tape at every joint, and a static pressure check before we leave.
Air Duct Replacement in Crowley
Air Duct Replacement in Crowley generally means pulling out all or most of the flex duct in your attic and installing new, properly supported runs from the plenum to every register. Homeowners along the US-287 growth corridor, especially in homes built between 1998 and 2012, are hitting the age where full replacement makes more financial sense than repeatedly patching failing sections. A whole-home flex duct replacement in Crowley typically runs $2,600 to $4,800 for a single-story 1,500 to 2,000 square foot house. That includes new boots, new collars, mastic sealing, and support straps at code spacing.
When Repair Is Not Enough
If we open a section of flex duct and the liner has delaminated from the jacket, there’s no sealing that. If the duct is crushed flat for more than a few feet, running a camera through it tells us the air has been choking for years. At that point, replacement is the honest answer. We’ll show you the camera footage before you spend a dollar on new material.
Whole-Home vs. Partial Replacement
Sometimes only the trunk line at the center of the house is shot, or only the runs serving the rooms on the west side. We’ll price partial replacement honestly, but we’ll also tell you when matching old duct to new creates static pressure problems of its own. In most Crowley attics with original 2000s flex duct, the most cost-effective move is replacing it all in one visit while the equipment and crew are already on site.
Trusted Brands We Service in Crowley
We work with professional-grade equipment from Rotobrush and Nikro, and we install and service air-quality products from Aprilaire and Abatement Technologies in Crowley homes. What that means for you is simple: if your system uses a specific brand of media filter cabinet, UV lamp, or in-duct air purifier, we know how it integrates. We stock common replacement parts locally so a repair visit doesn’t turn into a two-week parts wait. When a Crowley family needs a repair before a stretch of 100-degree days, that local inventory matters.
Common Air Duct Repair Problems We See in Crowley Homes
- Flex duct boots pulled off register boxes. The black gumbo clay under your slab swells in spring and shrinks in late summer. That movement can pull a boot 1 to 2 inches off the register box, letting attic air and dust pour into rooms you live in. We reconnect and seal these joints with mastic, not duct tape.
- Sagging internal liners in old flex duct. Mylar jackets break down after 15 to 20 years in a hot Crowley attic. The internal liner drops between supports, which restricts airflow and loads your blower motor. We see this in nearly every early-2000s home we open up.
- Return plenum disconnections pulling attic particulate. When a return plenum separates even a half inch, the negative pressure pulls blown-in insulation fibers, dust, and whatever else lives in your attic straight into your supply air. We reseal these with mechanical fasteners plus mastic, not just caulk.
- Crushed runs near the air handler. The area right above the air handler sees foot traffic, storage boxes, and the occasional misstep from cable installers or roofers. A crushed flex run can cut airflow to an entire side of the house. We replace crushed sections with properly supported runs and check static pressure after the fix.
Pricing for Air Duct Repair in Crowley, TX
Here’s what Crowley homeowners can expect. A single boot reconnection with mastic sealing runs $180 to $320. Repairing a section of separated or sagging flex duct with new material runs $250 to $550 per run. A full-home flex duct replacement in a 1,500 to 2,000 square foot Crowley house typically lands between $2,600 and $4,800, depending on the number of runs and attic access. What affects the final number is how many boots show signs of clay-shift damage and whether any plenums need rebuilding. Before any work, you get a written price per system. One flat number. After the work, you get a written 365-day guarantee. Call (980) 447-2498 for a free, no-commitment quote specific to your home.
Key Takeaways
- Most Crowley duct repair jobs involve reconnecting flex boots pulled off by slab movement, not just cleaning.
- Expect to pay $180 – $320 for a single boot reconnection and $2,600 – $4,800 for a full home flex duct replacement.
- You’ll always receive a written price before work starts and a written 365-day guarantee on every repair.
We Also Serve Cities Near Crowley
Our Air Duct Repair crews cover all of Crowley and regularly work in Burleson, Joshua, Kennedale, and Arlington. If you’re in one of those nearby cities, especially in Burleson’s newer sections where soil conditions differ from what we see along McAlister Road in Crowley, we can send a technician who knows what your ductwork actually needs.
Serving Crowley, TX - Our Local Coverage Area
We’re based in the Crowley area and know this community well. Use the map below to see our service coverage - if you’re nearby, we can almost certainly help.
FAQs About Air Duct Repair in Crowley
The expansive black gumbo clay under Crowley slabs swells and shrinks with seasonal moisture changes, physically moving the foundation enough to pull flex duct boots 1 to 2 inches off register boxes. This is the most common repair we perform in Crowley homes, especially in living areas near the center of the slab. We reconnect the boot with mechanical fasteners, seal the joint with mastic, and then check all other boots on the same trunk line. Call (980) 447-2498 if you suspect a disconnected boot; a camera inspection takes under an hour.
Most Crowley homes were built between the late 1990s and early 2010s, which puts the original flex duct at 15 to 25 years old. At that age, mylar jackets have degraded, internal liners are sagging between supports, and years of North Texas dust have compacted inside every trunk line. Homes in this age range almost always need more than a simple cleaning; they need reconnections, sealing, and often replacement of failing runs. The good news is that we’ve worked on hundreds of these exact homes along the US-287 corridor, so we know what to expect before we open the attic access.
In a typical Crowley home, a camera inspection shows dust and particulate buildup in the first 10 to 15 feet of the supply trunk, at least one boot pulled away from a register box, and often a return plenum gap pulling in attic insulation fibers. On a slab-on-grade home off McAlister Road built in the early 2000s, our crew ran a camera inspection and found the main trunk flex duct boot pulled an inch and a half away from the register box in the living room, a classic black gumbo clay shift. We reconnected the boot, sealed the joint, and replaced a crushed run near the air handler, cutting the attic dust pull and dropping static pressure enough that the blower motor stopped straining. Every repair includes a camera-verified before and after record.
Because Crowley’s ducts collect a specific mix of farm dust blown in from the open agricultural land south toward Alvarado, mountain cedar pollen in winter, oak pollen in spring, and attic insulation fibers pulled through boot disconnections. Blowing compressed air through the registers just pushes that debris around inside the runs. Source removal using negative-pressure extraction actually pulls the material out of the ductwork. We use professional-grade Rotobrush and Nikro equipment for this work, and we combine it with the sealing and reconnection work that Crowley ducts almost always need.
Extreme summer heat keeps Crowley HVAC systems running nearly continuously from May through September, which accelerates particulate deposition inside ducts at a rate faster than northern Texas suburbs. Meanwhile, the region’s prevailing south winds push both farm dust and high spring pollen directly into return air intakes. Combined with the foundation movement from black gumbo clay, the climate means ducts in Crowley need inspection and repair more often than in cities with stable soil and shorter cooling seasons. Schedule a free estimate at (980) 447-2498 if it’s been more than five years since anyone looked inside your ductwork.
Written by Marcus Veale, Owner at Linden Air Duct Cleaning, serving Crowley since 2004.